Brian's '96

User avatar
BDKW1
Posts: 1518
Joined: Mon Jun 14, 2010 1:19 pm
Bronco Info: It's the new and inproved Party Barge!
Location: Not Socal

Re: Brian's '96

Post by BDKW1 »

You have 10 active coils, what's the wire diameter and the ID of the coils?

350 would be a pretty good rate.......... With a tender spring..........
User avatar
yikes
Founder
Posts: 4138
Joined: Sun Dec 06, 2009 7:51 am
Bronco Info: 1996 with tires and stuff
Location: Yucaipa, CA

Re: Brian's '96

Post by yikes »

BDKW1 wrote:You have 10 active coils, what's the wire diameter and the ID of the coils?

350 would be a pretty good rate.......... With a tender spring..........

Coil ID is 4.50", wire diameter is approximately .706...under the powdercoat and yeah, 10 active coils.
User avatar
yikes
Founder
Posts: 4138
Joined: Sun Dec 06, 2009 7:51 am
Bronco Info: 1996 with tires and stuff
Location: Yucaipa, CA

Re: Brian's '96

Post by yikes »

Interesting....Using FOA's spring calculator for a beam suspension I get a required spring rate of 236lbs, which for a dual rate set-up would be a 590 primary with a 380?? tender. Using a couple of other po-dunk calculators, my springs are showing in the 240 range. What's not factored in to most of these is the torsional modulus, which is an unknown, but appears to have a significant impact on the rate.

All things considered, it appears these should be relatively close to what I need, but a tender may be necessary to get the proper ride height....just thinking out loud here.
User avatar
philofab
Basura Blanca
Posts: 5643
Joined: Tue Dec 08, 2009 9:37 am
Bronco Info: A pile of crap.
Location: Bullhead, AZ
Contact:

Re: Brian's '96

Post by philofab »

Something I have encountered with beam suspensions is since the track width changes so much through travel is they stay up until you roll them back and forth a bit. Could that been what happened or do you just have the adjuster all the way down so the coil hardware doesn't fall out?

You may look to circle track stuff for a tender spring... they use a lot of 5" coils.
Follow me on Instagram. @philofab1 or Youtube https://www.youtube.com/philofab/
User avatar
BDKW1
Posts: 1518
Joined: Mon Jun 14, 2010 1:19 pm
Bronco Info: It's the new and inproved Party Barge!
Location: Not Socal

Re: Brian's '96

Post by BDKW1 »

yikes wrote:All things considered, it appears these should be relatively close to what I need, but a tender may be necessary to get the proper ride height....just thinking out loud here.
Ding ding, winner....... I know on rangers, for a 3" X 14" shock we use a 300# X 2" spring with a 150# X 5" tender........ The tender spring is almost completely collapsed at ride height and the firmer bottom rate helps control the body roll without getting to harsh.
User avatar
yikes
Founder
Posts: 4138
Joined: Sun Dec 06, 2009 7:51 am
Bronco Info: 1996 with tires and stuff
Location: Yucaipa, CA

Re: Brian's '96

Post by yikes »

I got a thread going on RDC to see if I could get some help on this. King, SAW and Eibach have been dead ends. King recommended Blue Coil Products for custom springs. Brian said they are very reasonable for one-offs.
User avatar
BDKW1
Posts: 1518
Joined: Mon Jun 14, 2010 1:19 pm
Bronco Info: It's the new and inproved Party Barge!
Location: Not Socal

Re: Brian's '96

Post by BDKW1 »

Still like the Neckcar spring cut in half idea, only I fooked up on the rate. Cutting it in half will double the rate. So going with the 100# spring would net you about a 200# rate when it was cut in half. The 150# would end up being too stiff. To bad they don't make a 75# spring........
MOSS2
Posts: 317
Joined: Mon Dec 14, 2009 8:28 pm
Location: Northern California
Contact:

Re: Brian's '96

Post by MOSS2 »

I have used these guys for springs at work. They have a lot of stuff and will custom make. http://centuryspring.aitrk.com/

Ken
User avatar
yikes
Founder
Posts: 4138
Joined: Sun Dec 06, 2009 7:51 am
Bronco Info: 1996 with tires and stuff
Location: Yucaipa, CA

Re: Brian's '96

Post by yikes »

Thanks Ken. I've used Century quite a bit myself at work. Maybe I should give them a go for this too. I contacted Blue Coil. They'll do a one-off set for $240. That works for me.
Dust
Posts: 781
Joined: Fri Mar 12, 2010 1:41 pm
Bronco Info: Go Slow Ford's From 1957 to 1994
Location: Central Oregon

Re: Brian's '96

Post by Dust »

So Iz quieter here then RDC.
What size Delrin billet are you looking for?
Could you live with white?

I just might have a source.
User avatar
yikes
Founder
Posts: 4138
Joined: Sun Dec 06, 2009 7:51 am
Bronco Info: 1996 with tires and stuff
Location: Yucaipa, CA

Re: Brian's '96

Post by yikes »

Dust wrote:So Iz quieter here then RDC.
What size Delrin billet are you looking for?
Could you live with white?

I just might have a source.

Ooooh! White or natural is fine. I need 6" diameter by 10" min long or two 5" long pieces. Thanks!



Blue Coil was a no go on the springs. Once they crunched some numbers, they said it was impossible to make with a 150lb rate. Didn't have time to ask questions, but they said they may have some 250lb springs that would fit the bill. Don't think that'll work though.
Dust
Posts: 781
Joined: Fri Mar 12, 2010 1:41 pm
Bronco Info: Go Slow Ford's From 1957 to 1994
Location: Central Oregon

Re: Brian's '96

Post by Dust »

yikes wrote:
Dust wrote:So Iz quieter here then RDC.
What size Delrin billet are you looking for?
Could you live with white?

I just might have a source.

Ooooh! White or natural is fine. I need 6" diameter by 10" min long or two 5" long pieces. Thanks!



Blue Coil was a no go on the springs. Once they crunched some numbers, they said it was impossible to make with a 150lb rate. Didn't have time to ask questions, but they said they may have some 250lb springs that would fit the bill. Don't think that'll work though.
Give me a day to make a call.
User avatar
BDKW1
Posts: 1518
Joined: Mon Jun 14, 2010 1:19 pm
Bronco Info: It's the new and inproved Party Barge!
Location: Not Socal

Re: Brian's '96

Post by BDKW1 »

To bad your shocks are so damn big, I have a large supply of these......

Image
User avatar
yikes
Founder
Posts: 4138
Joined: Sun Dec 06, 2009 7:51 am
Bronco Info: 1996 with tires and stuff
Location: Yucaipa, CA

Re: Brian's '96

Post by yikes »

BDKW1 wrote:To bad your shocks are so damn big, I have a large supply of these......

Haha! Well, if I would have known that, I would have bought smaller. Dernit!


I decided to contact RGM to see if I could get any help there. What do you think? Fat chance? We'll see.
User avatar
David Kennedy
Posts: 39
Joined: Thu Dec 10, 2009 1:28 pm
Location: Los Angeles
Contact:

Re: Brian's '96

Post by David Kennedy »

I know he spoke about selling shocks to the public at the 2009 Dakar....
User avatar
BDKW1
Posts: 1518
Joined: Mon Jun 14, 2010 1:19 pm
Bronco Info: It's the new and inproved Party Barge!
Location: Not Socal

Re: Brian's '96

Post by BDKW1 »

Pretty sure Roger is the guy that handles the shock stuff. Call the shop and he can probably point you in the right direction if he can't take care of you.
User avatar
SteveG
Admin
Posts: 6142
Joined: Sat Dec 05, 2009 10:25 am
Bronco Info: Wilson: 96, Stretched 17.5", coil-overs / Bypasses, 4-link, a fridge and all the amenities :)
Location: Arroyo Grande, CA

Re: Brian's '96

Post by SteveG »

Who's idea was it to use those stupidly large shocks anyway!?
Sho nuff,
SteveG
Dust
Posts: 781
Joined: Fri Mar 12, 2010 1:41 pm
Bronco Info: Go Slow Ford's From 1957 to 1994
Location: Central Oregon

Re: Brian's '96

Post by Dust »

SteveG wrote:Who's idea was it to use those stupidly large shocks anyway!?
I don't know but they must be a BAD influence...

+/-7.5"D x 10"L White Delrin.
I can get you a scrap piece for $100-Max, maybe in the $75 range.
I'm looking at some other materials so it just depends on the final deal.
How far out do I want to reach in this blasted economy.
Iit's only money right... wish the flow would change directions :lol:
Shipping... I'll see if I can get a weight.

Chris
User avatar
yikes
Founder
Posts: 4138
Joined: Sun Dec 06, 2009 7:51 am
Bronco Info: 1996 with tires and stuff
Location: Yucaipa, CA

Re: Brian's '96

Post by yikes »

Awesome Chris!! Thanks for taking the time to check that out. Hopefully my 3 jaw will accept that monster. At least it won't take long to whittle down.
Dust
Posts: 781
Joined: Fri Mar 12, 2010 1:41 pm
Bronco Info: Go Slow Ford's From 1957 to 1994
Location: Central Oregon

Re: Brian's '96

Post by Dust »

yikes wrote:Awesome Chris!! Thanks for taking the time to check that out. Hopefully my 3 jaw will accept that monster. At least it won't take long to whittle down.
>Note<
First Delrin (acetal resin) is fun to machine! BUT be aware that when heated like turning it on the lathe, it out-gasses formaldehyde. Some people react to it so be aware if you get a headache FAST get out in the fresh air and get more air in you shop space. Good ventilation is a must. Use a fan and open the door!!!!!!

Second collect the chips and put them in zip-loc bags, If you happen to be a shooter put all your dirty patches in there to. You now have an emergency fire-starter that burns and sticks to the wood, just don't stand down wind.
Do NOT do this with polyurethane shavings... Delrin is one thing, that stuff can be fatal.


PM ya as soon as I set the deal.
C
Post Reply